Document Type : Research Article-en
Authors
1 Department of Food Science and Technology, Faculty of Agriculture, Jahrom University, Jahrom, Iran.
2 Department of Food Science and Technology, Faculty of Agriculture, Ferdowsi university of Mashhad,
3 Department of Food Science and Technology, Faculty of Agriculture, Ferdowsi University of Mashhad, Mashhad, Iran.
Abstract
UF- Feta cheese is mostly produced from bovine milk and is usually consumed fresh or only after a short period of ripening (60 days). In this research, the influence of commercial starter cultures (SafeIT 2, FRC- 65 and R- 704) and ripening time (0- 60 days) on chemical (total solids, fat, protein, ash, salt, acidity, pH), biochemical (pH 4.6, TCA, PTA-soluble nitrogen, acid degree value) and sensory (color and appearance, aroma, texture, flavor and total acceptance) characteristics of UF- Feta cheese analogues was investigated. According to our results, the starter culture types were known to have a significant effect (P≤ 0.05) on pH, %salt, %protein, and pH 4.6- soluble nitrogen of cheeses, whereas the other chemical properties were not affected by them. Ripening time only significantly (P≤ 0.05) influenced %acidity, pH, %salt, acid degree value (meq acid 100 g-1 fat), %protein and %proteolysis products of samples. Also, the starter culture and ripening time did not affect the sensory properties significantly, excluding color and appearance, however, the produced cheeses from SafeIT 2 had higher sensory scores compared with the others containing FRC- 65 and R- 704 cultures.
Keywords
Main Subjects
Al-Otaibi, M. M. & Wilbey, R. A. (2005). Effect of chymosin and salt reduction on the quality of ultrafiltrated white-salted cheese. Journal of dairy research, 72, 234-242.
Al-Otaibi, M. M. & Wilbey, R. A. (2006). Effect of chymosin reduction and salt substitution on the properties of white salted cheese. International Dairy Journal, 16, 903-909.
Al‐Otaibi, M. M. & Wilbey, R. A. (2004). Effect of temperature and salt on the maturation of white‐salted cheese. International Journal of Dairy Technology, 57, 57-63.
Alonso, R., Picon, A., Rodríguez, B., Gaya, P., Fernández-García, E. & Nuñez, M. (2011). Microbiological, chemical, and sensory characteristics of Hispánico cheese manufactured using frozen high pressure treated curds made from raw ovine milk. International Dairy Journal, 21, 484-492.
Aly, M. (1995). An attempt for producing low-sodium Feta-type cheese. Food chemistry, 52, 295-299.
AOAC (2005). Official Methods of Analysis of the AOAC (Association of Official Analytical Chemists) International, G. W. Latimer and W. Horwitz (Eds.), 18th ed, in total solids (TS) matter (oven-drying method) method 926.08, ash (incineration at 550ºC method) method 935.42, acidity (titration method) method 920.124, protein and nitrogen contents(micro-Kjeldahl method) method 920.123, Gaithersburg, MD.
Atasoy, A. F. & Türkoğlu, H. (2009). Lipolysis in Urfa cheese produced from raw and pasteurized goats’ and cows’ milk with mesophilic or thermophilic cultures during ripening. Food chemistry, 115, 71-78.
Avila, M., Calzada, J., Garde, S. & Nunez, M. (2007). Effect of a bacteriocin-producing Lactococcus lactis strain and high-pressure treatment on the esterase activity and free fatty acids in Hispánico cheese. International Dairy Journal, 17, 1415-1423.
Azarnia, S., Ehsani, M. & Mirhadi, S. (1997). Evaluation of the physico-chemical characteristics of the curd during the ripening of Iranian brine cheese. International Dairy Journal, 7, 473-478.
Beresford, T. & Williams, A. (2004). The microbiology of cheese ripening. Cheese: chemistry, physics and microbiology, 1, 287-317.
BSI (1989). Standard no. 696: Gerber method for the determination of fat in milk and milk products. London, UK: British Standards Institution.
Collins, Y., McSweeney, P. & Wilkinson, M. (2004). Lipolysis and catabolism of fatty acids in cheese. Cheese: chemistry, physics and microbiology, 1, 373-389.
Courtin, P., Nardi, M., Wegmann, U., Joutsjoki, V., Ogier, J., Gripon, J., Palva, A., Henrich, B. & Monnet, V. (2002). Accelerating cheese proteolysis by enriching Lactococcus lactis proteolytic system with lactobacilli peptidases. International Dairy Journal, 12, 447-454.
Daly, D. F., McSweeney, P. L. & Sheehan, J. J. (2010). Split defect and secondary fermentation in Swiss-type cheeses–A review. Dairy science & technology, 90, 3-26.
de Oliveira Carneiro, J., Chaves, A. C. S. D., Stephan, M. P., Boari, C. A. & Koblitz, M. G. B. (2020). Artisan minas cheese of Serro: proteolysis during ripening. Heliyon, 6, 04446.
Di Cagno, R., De Angelis, M., Upadhyay, V. K., McSweeney, P. L., Minervini, F., Gallo, G. & Gobbetti, M. (2003). Effect of proteinases of starter bacteria on the growth and proteolytic activity of Lactobacillus plantarum DPC2741. International Dairy Journal, 13, 145-157.
Fathollahi, I., Hesari, J., Azadmard, S. & Oustan, S. (2010). Influence of proteolysis and soluble calcium levels on textural changes in the interior and exterior of Iranian UF white cheese during ripening. World Acad. Sci. Eng. Technol, 66, 844-849.
Georgala, A., Moschopoulou, E., Aktypis, A., Massouras, T., Zoidou, E., Kandarakis, I. & Anifantakis, E. (2005). Evolution of lipolysis during the ripening of traditional Feta cheese. Food chemistry, 93, 73-80.
Ghods Rohani, M., Mortazavi, S. & Tehrani, M. (2010). Effect of storage period on physical, chemical and sensory properties of ultrafiltrated feta cheese made from cow's milk and soymilk blend. Iranian Food Science & Technology Research Journal, 6, 149-157.
Gholamhosseinpour, A., Mazaheri Tehrani, M. & Razavi, S. M. A. (2018). Optimization of textural characteristics of analogue UF-Feta cheese made from dairy and non-dairy ingredients. Iranian Journal Food Science and Technology Research, 13, 80-91.
Gholamhosseinpour, A., Mazaheri Tehrani, M., Razavi, S. M. A. & Rashidi, H. (2014). Evaluation and optimization of chemical and sensory properties of various formulations of recombined UF-Feta cheese analogues using response surface methodology. Iranian Food Science and Technology Research Journal, 10, 107-121.
Gobbetti, M., Burzigotti, R., Smacchi, E., Corsetti, A. & De Angelis, M. (1997a). Microbiology and biochemistry of Gorgonzola cheese during ripening. International Dairy Journal, 7, 519-529.
Gobbetti, M., Lowney, S., Smacchi, E., Battistotti, B., Damiani, P. & Fox, P. F. (1997b). Microbiology and biochemistry of Taleggio cheese during ripening. International Dairy Journal, 7, 509-517.
Gobbetti, M., Smacchi, E. & Corsetti, A. (1997c). Purification and characterization of a cell surface-associated esterase from Lactobacillus fermentum DT41. International Dairy Journal, 7, 13-21.
Gomez, M., Rodriguez, E., Gaya, P., Nunez, M. & Medina, M. (1999). Characteristics of Manchego cheese manufactured from raw and pasteurized ovine milk and with defined-strain or commercial mixed-strain starter cultures. Journal of Dairy Science, 82, 2300-2307.
Grattepanche, F., Audet, P. & Lacroix, C. (2007). Enhancement of functional characteristics of mixed lactic culture producing nisin Z and exopolysaccharides during continuous prefermentation of milk with immobilized cells. Journal of Dairy Science, 90, 5361-5373.
Guinee, T. (2007). Introduction: what are analogue cheeses. Cheese problems solved. Woodhead Publishing Limited, Cambridge, and CRC Press LLC, Boca Raton, 384-386.
Hannon, J., Deutsch, S.-M., Madec, M.-N., Gassi, J.-Y., Chapot-Chartier, M.-P. & Lortal, S. (2006). Lysis of starters in UF cheeses: behaviour of mesophilic lactococci and thermophilic lactobacilli. International Dairy Journal, 16, 324-334.
Hayaloglu, A., Guven, M., Fox, P. & McSweeney, P. (2005). Influence of starters on chemical, biochemical, and sensory changes in Turkish white-brined cheese during ripening. Journal of Dairy Science, 88, 3460-3474.
Hayaloglu, A., Tolu, C. & Yasar, K. (2013). Influence of goat breeds and starter culture systems on gross composition and proteolysis in Gokceada goat cheese during ripening. Small Ruminant Research, 113, 231-238.
Hayaloglu, A. A., Fox, P. F., Guven, M. & Cakmakci, S. (2007). Cheeses of Turkey: 1. Varieties ripened in goat-skin bags. Le Lait, 87, 79-95.
Hynes, E., Ogier, J.-C., Son, O. & Delacroix-Buchet, A. (2003). Influence of starter and adjunct lactobacilli culture on ripening of miniature washed-curd cheeses. Le Lait, 83, 17-29.
IDF (1988). Cheese and processed cheese-determination of salt content. Standard 12 B. Brussels, Belgium: International Dairy Federation.
Iran Standard no. 12736 (2010). Fresh cheese with vegetable oil (analog fresh cheese), Specification and test methods. National Standards Authority of Iran, Tehran, Iran.
Karami, M., Ehsani, M., Ebrahimzadeh mousavi, M., Rezaei, K. & Safari, M. (2009a). Profile of fatty acids, microstructure and physico-chemical properties of ultrafiltered feta cheese. Iranian Journal Of Biosystems Engineering (Iranian Journal Of Agricultural Sciences), 40, 101-110.
Karami, M., Ehsani, M., Mousavi, S., Rezaei, K. & Safari, M. (2009b). Changes in the rheological properties of Iranian UF-Feta cheese during ripening. Food chemistry, 112, 539-544.
Karami, M., Ehsani, M. R., Mousavi, M. E., Rezaei, K. & Safari, M. (2008). Microstructural Changes in fat during the ripening of Iranian ultrafiltered feta cheese. Journal of Dairy Science, 91, 4147-4154.
Karimi, R., Mortazavian, A. & Karami, M. (2012). Incorporation of Lactobacillus casei in Iranian ultrafiltered Feta cheese made by partial replacement of NaCl with KCl. Journal of Dairy Science, 95, 4209-4222.
Katsiari, M., Voutsinas, L. & Kondyli, E. (2002). Improvement of sensory quality of lowfat Kefalograviera-type cheese by using commercial special starter cultures. Journal of Dairy Science, 85, 2759-2767.
Korhonen, H. & Pihlanto, A. (2006). Bioactive peptides: production and functionality. International Dairy Journal, 16, 945-960.
Lacroix, N., St-Gelais, D., Champagne, C., Fortin, J. & Vuillemard, J.-C. (2010). Characterization of aromatic properties of old-style cheese starters. Journal of Dairy Science, 93, 3427-3441.
Larráyoz, P., Addis, M., Gauch, R. & Bosset, J. O. (2001). Comparison of dynamic headspace and simultaneous distillation extraction techniques used for the analysis of the volatile components in three European PDO ewes’ milk cheeses. International Dairy Journal, 11, 911-926.
Lopez, C., Camier, B. & Gassi, J.-Y. (2007). Development of the milk fat microstructure during the manufacture and ripening of Emmental cheese observed by confocal laser scanning microscopy. International Dairy Journal, 17, 235-247.
Manso, M., Léonil, J., Jan, G. & Gagnaire, V. (2005). Application of proteomics to the characterisation of milk and dairy products. International Dairy Journal, 15, 845-855.
Martı́nez-Cuesta, M. C., de Palencia, P. F., Requena, T. & Peláez, C. (2001). Enzymatic ability of Lactobacillus casei subsp. casei IFPL731 for flavor development in cheese. International Dairy Journal, 11, 577-585.
Messens, W., Estepar-Garcia, J., Dewettinck, K. & Huyghebaert, A. (1999). Proteolysis of high-pressure-treated Gouda cheese. International Dairy Journal, 9, 775-782.
Milci, S., Goncu, A., Alpkent, Z. & Yaygin, H. (2005). Chemical, microbiological and sensory characterization of Halloumi cheese produced from ovine, caprine and bovine milk. International Dairy Journal, 15, 625-630.
Miočinović, J., Puđa, P., Radulović, Z., Pavlović, V., Miloradović, Z., Radovanović, M. & Paunović, D. (2011). Development of low fat UF cheese technology. Mljekarstvo, 61, 33-44.
Moatsou, G., Massouras, T., Kandarakis, I. & Anifantakis, E. (2002). Evolution of proteolysis during the ripening of traditional Feta cheese. Le Lait, 82, 601-611.
Muir, D., Banks, J. & Hunter, E. (1996). Sensory properties of Cheddar cheese: effect of starter type and adjunct. International Dairy Journal, 6, 407-423.
Nunez, M., Garcia-Aser, C., Rodriguez-Martin, M., Medina, M. & Gaya, P. (1986). The effect of ripening and cooking temperatures on proteolysis and lipolysis in Manchego cheese. Food chemistry, 21, 115-123.
Özer, B., Robinson, R. & Grandison, A. (2003). Textural and microstructural properties of urfa cheese (a white‐brined Turkish cheese). International Journal of Dairy Technology, 56, 171-176.
Pappa, E. C., Kandarakis, I. G., Zerfiridis, G. K., Anifantakis, E. M. & Sotirakoglou, K. (2006). Influence of starter cultures on the proteolysis of Teleme cheese made from different types of milk. Le Lait, 86, 273-290.
Pezeshki, A., Hesari, J., Ahmadi Zonoz, A. & Ghambarzadeh, B. (2011). Influence of Withania coagulans Protease as a Vegetable Rennet on Proteolysis of Iranian UF White Cheese. Journal of Agricultural Science and Technology, 13, 567-576.
Pillidge, C., Crow, V., Coolbear, T. & Reid, J. (2003). Exchanging lactocepin plasmids in lactococcal starters to study bitterness development in Gouda cheese: a preliminary investigation. International Dairy Journal, 13, 345-354.
Reis, P. c. M., Lourenço, P. L., Domingos, A., Clemente, A. F., Pais, M. S. & Malcata, X. (2000). Applicability of extracts from Centaurea calcitrapa in ripening of bovine cheese. International Dairy Journal, 10, 775-780.
Santillo, A., Quinto, M., Dentico, M., Muscio, A., Sevi, A. & Albenzio, M. (2007). Rennet paste from lambs fed a milk substitute supplemented with Lactobacillus acidophilus: effects on lipolysis in ovine cheese. Journal of Dairy Science, 90, 3134-3142.
Sarantinopoulos, P., Andrighetto, C., Georgalaki, M. D., Rea, M. C., Lombardi, A., Cogan, T. M., Kalantzopoulos, G. & Tsakalidou, E. (2001). Biochemical properties of enterococci relevant to their technological performance. International Dairy Journal, 11, 621-647.
Shahab Lavasani, A. R., Ehsani, M. R., Mirdamadi, S. & Ebrahim Zadeh Mousavi, M. A. (2012). Changes in physicochemical and organoleptic properties of traditional Iranian cheese Lighvan during ripening. International Journal of Dairy Technology, 65, 64-70.
Sheehan, J., Patel, A., Drake, M. & McSweeney, P. (2009). Effect of partial or total substitution of bovine for caprine milk on the compositional, volatile, non-volatile and sensory characteristics of semi-hard cheeses. International Dairy Journal, 19, 498-509.
Souza, C. H. & Saad, S. M. (2009). Viability of Lactobacillus acidophilus La-5 added solely or in co-culture with a yoghurt starter culture and implications on physico-chemical and related properties of Minas fresh cheese during storage. LWT-Food Science and Technology, 42, 633-640.
Tavaria, F. K., Franco, I., Carballo, F. J. & Malcata, F. X. (2003). Amino acid and soluble nitrogen evolution throughout ripening of Serra da Estrela cheese. International Dairy Journal, 13, 537-545.
van Kranenburg, R., Kleerebezem, M., van Hylckama Vlieg, J., Ursing, B. M., Boekhorst, J., Smit, B. A., Ayad, E. H., Smit, G. & Siezen, R. J. (2002). Flavor formation from amino acids by lactic acid bacteria: predictions from genome sequence analysis. International Dairy Journal, 12, 111-121.
Vernile, A., Giammanco, G., Spano, G., Beresford, T. P., Fox, P. F. & Massa, S. (2008). Genotypic characterization of lactic acid bacteria isolated from traditional Pecorino Siciliano cheese. Dairy Science and Technology, 88, 619-629.
Wang, W., Bao, Y., Hendricks, G. M. & Guo, M. (2012). Consistency, microstructure and probiotic survivability of goats’ milk yoghurt using polymerized whey protein as a co-thickening agent. International Dairy Journal, 24, 113-119.
Wouters, J. T., Ayad, E. H., Hugenholtz, J. & Smit, G. (2002). Microbes from raw milk for fermented dairy products. International Dairy Journal, 12, 91-109.
Zárate, V., Belda, F., Pérez, C. & Cardell, E. (1997). Changes in the microbial flora of Tenerife goats' milk cheese during ripening. International Dairy Journal, 7, 635-641.
)
Send comment about this article