Comparison Astaxanthin Extraction of Fenneropenaeus merguiensis and Pontogammarus maeoticus by Using Organic Solvent, Sunflower Oil and Ionic Liquid Micro Emulsion

Document Type : Research Article

Authors

• Parisa Feizi ¹
• Yahya Maghsoudlou ¹
• Hoda Shahiri Tabarestani ¹
• Seyed Mahdi Jafari ¹
• Amir Bahri ²

¹ Department of Food Science & Technology, College of Food Technology, Gorgan University of Agricultural Sciences & Natural Resources, Gorgan, Iran

² Department of Fisheries, Bandar Abbas Islamic Azad University, Bandar Abbas, Iran

https://doi.org/10.22067/ifstrj.2023.82949.1265

Abstract

Introduction
 Astaxanthin is a widely used carotenoid pigment in the food industry which is extracted from various natural and synthetic sources. Nowadays, due to the adverse effects of organic solvents green solvents which are non-toxic, non-volatile and environmentally friendly have been proposed. Therefore, this study focuses on comparison of the extraction of astaxanthin from shrimp (Fenneropenaeus merguiensis) and Gammarus (Pontogammarus maeoticus) under soaking conditions for 24 hours with organic solvent (combination of ethanol with ethyl acetate), green solvent (microemulsion of ionic liquid in water) and vegetable oil (sunflower oil). Ionic liquid microemulsion in water is considered a newnovel solvent for astaxanthin extraction. Determination of density, conductivity and diameter were the characteristics of microemulsion test. In extraction,Solvent to sample ratios of 5x, 12.5x and 20x were used for the extraction and compared with the control sample.
 
Materials and Methods

merguiensis and P. maeoticus With species approval were procured from Persian Gulf Ecology Research Institute (Iran). Commercial astaxanthin (>98 % purity), α-diphenyl-β-picrylhydrazyl (DPPH), and butylated hydroxytoluene (BHT) were procured from Sigma-Aldrich (USA). The HPLC grade ethanol, propanol, ethyl acetate,, tributyl octyl phosphonium bromide, Triton X-100, and n-butanol were obtained from Merck Chemicals Co. (Germany). Refined sunflower oil which was antioxidant-free, was also purchased from Hayat Company (Iran). The shell of F. merguiensis and P. maeoticus were carefully washed with distilled water, then freeze-dried (Christ-Alpha 1–4, LD freeze dryer, Germany) for 48 h at -50 °C. After sieving the powders with a laboratory sieve with a mesh smaller than 15 µm. The obtained powders were kept at Refrigerator. All experiments were done in the Food and Drug Administration Department of Hormozgan University of Medical Sciences.

 
Results and Discussion
 According to the results, the density of the microemulsion was determined in the range of 0.97151 g/cm³, its diameter was 15.8 nanometers and the conductivity was 312 microsiemens at 27.1°C. The results of astaxanthin extraction with different solvents in the comparison with control solvent were statistically significant (p< 0.05). According to the results obtained from the extraction of astaxanthin from two sources of shrimp and gammarus, shrimp was selected as the source with the highest amount of extracted astaxanthin. The use of green solvent (ionic liquid microemulsion in water) in a ratio of 12.5 times solvent to sample was also chosen as the optimal method. The amount of astaxanthin extracted under optimal conditions was 77.44 ± 1.09 mg/ml. The results of DPPH radical inhibition by extracted astaxanthin using ionic, oily and organic solvents compared to synthetic antioxidant BHT showed that the antioxidant activity increased with increasing the concentration of astaxanthin, but this increase was always lower than BHT.
 
Conclusion
In general, the results of this research show that the use of microemulsion based on ionic liquids is a suitable alternative to conventional methods in extracting and recovering astaxanthin from natural biological sources.
 
Acknowledgement
We are grateful to the Honorable Vice-Chancellor of Hormozgan Food and Drug Administration for the help in using the Hormozgan Food and Drug Laboratory to conduct the experiments of this doctoral thesis.







 

Keywords

• Astaxanthin
• Ionic liquid micro emulsion
• Fenneropenaeus merguiensis
• Pontogammarus maeoticus

Main Subjects

• Food Technology

©2023 The author(s). This is an open access article distributed under Creative Commons Attribution 4.0 International License (CC BY 4.0), which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source.

References

1. Ambati, R.R., Siew Moi, P., Ravi, S., & Aswathanarayana, R.G. (2014). Astaxanthin: Sources, extraction, stability, biological activities and its commercial applications-A review. Marine drugs, 12(1), 128-152. https://doi.org/10.3390/md12010128
2. Amiri-Rigi, A., & Abbasi, S. (2019). Extraction of lycopene using a lecithin-based olive oil microemulsion. Food chemistry, 272, 568-573. https://doi.org/10.1016/j.foodchem.2018.08.080
3. Amiri-Rigi, A., Abbasi, S., & Scanlon, M.G. (2016). Enhanced lycopene extraction from tomato industrial waste using microemulsion technique: Optimization of enzymatic and ultrasound pre-treatments. Innovative Food Science & Emerging Technologies, 35, 160-167. https://doi.org/10.1016/j.ifset.2016.05.004
4. Amorim-Carrilho, K., Cepeda, A., Fente, C., & Regal, P. (2014). Review of methods for analysis of carotenoids. TrAC Trends in Analytical Chemistry, 56, 49-73. https://doi.org/10.1016/j.trac.2013.12.011
5. Brandão, L.B., Coêlho, D.F., Souza, R.R., & Silva, C.F. (2019). Technological prospection of astaxanthin recovery of shrimp waste litopenaeus vannamei by the vegetable oil extracton process. Revista INGI-Indicação Geográfica e Inovação, 3(465-475).
6. Delgado-Vargas, F., & Paredes-Lopez, O. (2002). Natural colorants for food and nutraceutical uses: CRC press.
7. Gao, J., You, J., Kang, J., Nie, F., Ji, H., & Liu, S. (2020). Recovery of astaxanthin from shrimp (Penaeus vannamei) waste by ultrasonic-assisted extraction using ionic liquid-in-water microemulsions. Food Chemistry, 325, 126850. https://doi.org/10.1016/j.foodchem.2020.126850
8. Haque, F., Dutta, A., Thimmanagari, M., & Chiang, Y.W. (2016). Intensified green production of astaxanthin from Haematococcus pluvialis. Food and BioproductsProcessing, 99, 1-11. https://doi.org/10.1016/j.fbp.2016.03.002
9. Hooshmand, H., Shabanpour, B., Moosavi‐Nasab, M., Alishahi, A., & Golmakani, M.T. (2021). The optimization of extraction of carotenoids pigments from blue crab (Portunus pelagicus) and shrimp (Penaeus semisulcatus) wastes using ultrasound and microwave. Journal of Marine Science and Technology, 20(2), 72-93. https://doi.org/10.22113/jmst.2018.105737.2084
10. Hooshmand, H., Shabanpour, B., Moosavi‐Nasab, M., & Golmakani, M.T. (2017). Optimization of carotenoids extraction from blue crab (Portunus pelagicus) and shrimp (Penaeus semisulcatus) wastes using organic solvents and vegetable oils. Journal of Food Processing and Preservation, 41(5), e13171.https://doi.org/10.1111/jfpp.13171
11. Khoo, K.S., Chew, K.W., Yew, G.Y., Manickam, S., Ooi, C.W., & Show, P.L. (2020). Integrated ultrasound-assisted liquid biphasicflotation for efficient extraction of astaxanthin from Haematococcus pluvialis. Ultrasonics Sonochemistry, 67, 105052. https://doi.org/10.1016/j.ultsonch.2020.105052
12. Kishimoto, Y., Tani, M., Uto-Kondo, H., Iizuka, M., Saita, E., Sone, H., & Kondo, K. (2010). Astaxanthin suppresses scavenger receptor expression and matrix metalloproteinase activity in macrophages. European Journal of Nutrition, 49(2), 119-126. https://doi.org/10.1007/s00394-009-0056-4
13. Martins, P.L.G., Braga, A.R., & de Rosso, V.V. (2017). Can ionic liquid solvents be applied in the foodindustry? Trends in Food Science & Technology, 66, 117-124. https://doi.org/10.1016/j.tifs.2017.06.002
14. Nikmaram, P., Mousavi, S.M., Emam-Djomeh, Z., Kiani, H., & Razavi, S.H. (2015). Evaluation and prediction of metabolite production, antioxidant activities, and survival of Lactobacillus casei 431 in a pomegranate juice supplemented yogurt drink using support vector regression. Food Science and Biotechnology, 24(6), 2105-2112. https://doi.org/10.1007/s10068-015-0279-5
15. Norshazila, S., Irwandi, J., Othman, R., & Zuhanis, H.Y. (2012). Scheme of obtaining [Beta]-carotene standard from pumpkin (Cucurbita moschata) flesh. International Food Research Journal, 19(2), 531.
16. Parjikolaei, B.R., Errico, M., El-Houri, R.B., Christensen, K.V., & Fretté, X.C. (2016). Green approaches to extract Astaxanthin from Shrimp waste: process design and economic evaluation. In Computer Aided Chemical Engineering, 38, 649-654. https://doi.org/10.1016/B978-0-444-63428-3.50113-2
17. Pérez-López, P., González-García, S., Jeffryes, C., Agathos, S.N., McHugh, E., Walsh, D., Moreira, M.T. (2014). Life cycle assessment of the production of the red antioxidant carotenoid astaxanthin by microalgae: from lab to pilot scale. Journal of Cleaner Production, 64, 332-344. https://doi.org/10.1016/j.jclepro.2013.07.011
18. Radi, M., & Abbasi, S. (2013). Microemulsions and their application in food industry, Nano Technology Monthly, No. 3.
19. Roohinejad, S., Oey, I., Everett, D., & Niven, B. (2014). Evaluating the effectiveness of β-carotene extraction from pulsed electric field-treated carrot pomace using oil-in-water microemulsion. Food and Bioprocess Technology, 7, 3336-334. https://doi.org/10.1007/s11947-014-1334-6
20. Ruen-ngam, D., Shotipruk, A., & Pavasant, P. (2010). Comparison of extraction methods for recovery of astaxanthin from Haematococcus pluvialis. Separation Science and Technology, 46(1), 64-70. https://doi.org/10.1080/01496395.2010.493546
21. Saini, R.K., & Keum, Y.-S. (2018). Carotenoid extraction methods: A review of recent developments. Food Chemistry, 240, 90-103. https://doi.org/10.1016/j.foodchem.2017.07.099
22. Silva, A.K.N.D., Rodrigues, B.D., Silva, L.H.M.D., & Rodrigues, A.M.D.C. (2018). Drying and extraction of astaxanthin from pink shrimp waste (Farfantepenaeus subtilis): the applicability of spouted beds. Food Science and Technology, 38, 454-461.
23. Sowmya, R., Ravikumar, T., Vivek, R., Rathinaraj, K., & Sachindra, N. (2014). Optimization of enzymatic hydrolysis of shrimp waste for recovery of antioxidant activity rich protein isolate. Journal of Food Science and Technology, 51, 3199-3207. https://doi.org/10.1007/s13197-012-0815-8
24. Tan, Y., Ye, Z., Wang, M., Manzoor, M.F., Aadil, R.M., Tan, X., & Liu, Z. (2021). Comparison of different methods for extracting the astaxanthin from Haematococcus pluvialis: Chemical composition and biological activity. Molecules, 26(12), 3569. https://doi.org/10.3390/molecules26123569
25. Zhao, X., Zhang, X., Fu, L., Zhu, H., & Zhang, B. (2016). Effect of extraction and drying methods on antioxidant activity of astaxanthin from Haematococcus pluvialis. Food and Bioproducts Processing, 99, 197-203. https://doi.org/10.1016/j.fbp.2016.05.007