Investigation on the Effects of Various Solvents on the Extraction of Carotenoids with Antioxidant Activity from Pumpkin

Document Type : Short Article

Authors

• Javad Mahdizadeh Moghadam ¹
• Somaye Rahimi ²

¹ Department of Food Science and Technology, Faculty of Novel Science and Technology, Pharmaceutical Sciences Branch, Islamic Azad University, Tehran, Iran.

² Department of Food Technology, Institute of Chemical Technologies, Iranian Research Organization for Science and Technology (IROST), Tehran, Iran.

https://doi.org/10.22067/ifstrj.v1395i0.48796

Abstract

Introduction: Pumpkin is one of the agricultural products that despite its very low price, is known as a rich source of carotenoids with high antioxidant activity. Iran is one of the good producers of pumpkin at the world with fifth rank which is cultivated at provinces like Mazandaran, Guilan, Khorasan, and Hamedan and so on extensively. Pumpkin is almost available for entire the year but many of them is spoiled and perished because of low storage equipments; on the other hand, unfortunately this valuable vegetable which is full of many types of carotenoids with high nutritive values, is not consumed by most of Iranian peoples, because of its low sensory properties such as no pleasant taste or odor; whereas it is used at many cuisines at other countries, especially North America. The pumpkin carotenoids contain natural pigment, beta- carotene and lycopene which can be used as natural colorant at food processed products or dietary supplements. Nowadays, the positive health effect of carotenoids such as improvement of eyesight, fetus growth, prevention from cardiovascular disease and cancer, maintenance of skin health and whole of body, anti blood hypertension and cholesterol is known, well, hence it must more be emphasized at household food basket. There are many researches about extraction of carotenoids form tomato, carrot, yeast and so on, but studying the pumpkin carotenoids was done less. Generally, due to the hydrophobic characteristic of carotenoids and their little solubility at water, organic solvents such as hexane are applied for their extraction, which some researches had been done about its solubility at different organic solvents, yet.

Materials and methods: In this research the ripped pumpkins (Curcurbita moschata) were cultivated at private farm at Khorasan were rinsed and chopped to same cubes. Then, pumpkin cubes were peeled off and the seeds were removed. For extraction of carotenoids, the pumpkin specimens prepared at four states of raw (mashed pumpkin), cooked (mashed pumpkin), dried (40 C) (powder) and dry powder of cooked pieces (40 C). Carotenoids were extracted from pumpkin samples by various organic solvents such as hexane, acetone, ethanol, at different volume ratio of them like 1:1(v) and 1:1:1(v). When the pumpkins became colorless, the extract had been evaporated at a vacuumed rotating evaporator to gain a thick extract without any solvent. The extract had been gathered and stored at black bottles and refrigerator to minimize the side effects of light and heat on nutritive characteristics of carotenoids. The total carotenoids content of the pumpkin extracts was measured by spectrophotometric method at 480 nm according to beta- carotene. The antioxidant activity of the extracts was calculated on the basis of DPPH scavenging activity of the samples at 517 nm. The project was done on a complete random design and one-way ANOVA and Duncan test were used for statistical data analysis and clearance the significant difference among treatments at 95% confidence level.

Results & Discussions: Statistical analysis of the results showed that various organic solvents, their volume ratio and also various state of pumpkin specimens had a significant effect on the carotenoid extraction from pumpkin samples (p

Keywords

• Pumpkin
• Exrtraction
• Carotenoid
• DPPH

References

Amorim-Carrilho, K.T., Cepeda, A., Fente, C., & Regal, P. 2014. Review of methods for analysis of carotenoids. Trends in Analytical Chemistry, 56: 49–73.

Azizah, A. H., Wee, K. C., Azizah, O., & Azizah, M. 2009. Effect of boiling and stir frying on total phenolics, carotenoids and radical scavenging activity of pumpkin (Cucurbita moschato). International Food Research Journal, 16: 45–51.

Barth, M. M., Zhou, C., Kute, K. M., & Rosenthal, G. A. 1995. Determination of optimum conditions for supercritical fluid extraction of carotenoids from carrot (Daucus carota L.) tissue. Journal of Agriculture and Food Chemistry, 43: 2876–2878.

de Carvalho, L. M. J., Gomes, P. B., de Oliveira Godoy, R. L., Pacheco, S., do Monte, P. H. F., de Carvalho, J. L. V., Nutti, M. R., Neves, A. C. L., Vieira, A. C. R. A., & Ramos, S. R. R. 2012. Total carotenoid content, α-carotene and β-carotene, of landrace pumpkins (Cucurbita moschata Duch): A preliminary study. Food Research International, 47: 337–340.

Griffiths, J. C. 2005. Coloring Foods & Beverages. Food Technology, 59: 38–44.

Gu, Z., Chen, D., Han, Y., Chen, Z., & Gu, F. 2008. Optimization of carotenoids extraction from Rhodobacter sphaeroides. LWT- Food Science and Technology, 41: 1082–1088.

Ishida, B. K., & Chapman, M. H. 2008. Carotenoid extraction from plants using a novel, environmentally friendly solvent. Journal of Agriculture and Food Chemistry, 57: 1051–1059.

Norshazila, S., Irwandi, J., Othman, R., & Yumi Zuhanis, H. H. 2012. Scheme of obtaining β-carotene standard from pumpkin (Cucurbita moschata) flesh. International Food Research Journal, 19(2): 531–535

Prasad, K. N., Chew, L. Y., Khoo, H. E., Yang, B., Azlan, A., & Ismail, A. 2011. Carotenoids and antioxidant capacities from Canarium odontophyllum Miq. Fruit. Food chemistry, 124: 1549-1555.

Seo, J. S., Burri, B. J., Quan, Z., & Neidlinger, T. R. 2005. Extraction and chromatography of carotenoids from pumpkin. Journal of Chromatography A, 1073: 371–375.

Shi, J., Yi, C., Ye, X., Xue, S., Jiang, Y., Ma, Y., & Liu, D. 2010. Effects of supercritical CO2 fluid parameters on chemical composition and yield of carotenoids extracted from pumpkin. LWT - Food Science and Technology, 43: 39–44.

Shi, X., Wu, H., Shi, J., Xue, S., Wang, D., Wang, W., Cheng, A., Gong, Z., Chen, X., & Wang, C. 2013. Effect of modifier on the composition and antioxidant activity of carotenoid extracts from pumpkin (Cucurbita maxima) by supercritical CO2. LWT - Food Science and Technology, 51: 433–440.

Thompson, K. A., Marshall, M. R., Sims, C. A., Wei, C. I., Sargent, S. A., & Scott, J. W. 2000. Cultivar, maturity, and heat treatment on lycopene content in tomatoes. Journal of Food Science, 65 (5): 791–795.