Evaluation of Ethyl Oleate, Sodium Chloride and Blanching Pretreatments on Vacuum Drying of Sweet Pepper (Capsicum annum)

Document Type : Full Research Paper

Authors

• Narmela Asefi
• Nasibeh Alirezaloo
• Pouya Barman Veisi
• Haleh Soraiyay Zafar

Department of Food Science and Technology, Islamic Azad University, Tabriz branch, Tabriz, Iran

https://doi.org/10.22067/ifstrj.2021.70205.1040

Abstract

Introduction
 Sweet Pepper (Capsicum annum) has a very important place among the vegetables produced in the world. Therefore, it is necessary to apply practical solutions to increase their sustainability to develop and improve production. The growing consumer rejection of chemical additives and the demand for more natural products have increased attention to some methods, including the drying method. One of the physical changes that occur during the drying of food is its reduction in volume. Vacuum drying is a method in which water and other solvents that have been absorbed into the volume or surface of the material are removed. Combining vacuum with heating can be an effective way to dry; because in this case, a high level of dryness can be achieved without the need for a large increase in temperature. A thermal process that is applied to vegetables and fruits as a pre-process step for freezing, drying and canning to inactivating enzymes, modifying texture, preserving flavor and nutrients, and extracting Interstitial air. 
 
Materials and Methods
 This study aimed to investigate the impact of various factors ethyloleate (concentrations 0,2,4%), sodium chloride(concentrations 0,2,4%) and blanching on the drying kinetics, physical properties, chemical composition and nutrients of green bell pepper, dried under vacuum at 60°C and pressure of 10 kpa using the response surface methodology. At the end of the drying time, 10 g of the treated samples were weighted to investigate the drying kinetics and the rest of the samples were kept for analysis. To achieve the drying kinetics, the samples were taken out of the oven (Behdad Company, model 3494, made in Iran) at 30 minute intervals and weighed by a digital scale, and dried down to moisture content of 12% ., and then for relevant analyzes on dried samples, the samples were stored in plastic packages until the day of experiments. Investigation of independent and interaction effects of immersion in different concentrations of sodium chloride and ethyloleate solution on the kinetics and drying time separately in blanching and non-blanching samples on the parameters of color, chlorophyll content, phenolic substances and vitamin C remaining in dried Sweet peppers were evaluated using minitab16 software and response level method (RSM).
 
Results and Discussion
 The results showed that the drying process occur in the range of falling rate and also effect blanching in boiling water for 3 minutes and immersed in an alkaline solution of ethyloleate and sodium chloride with concentrations of 2 and 4% for 1 minute, significantly increase the drying rate. In blanching and treated samples with 4% ethyloleate and sodium chloride, the drying time was about 3.5 hours, while the control sample was dried under the same conditions for 7.5 hours. Pretreatment of samples, showed the chlorophyll content, phenolic compounds and vitamin C were higher than the control sample. Due to the effectiveness of ethyloleate in the protection of ascorbic acid, phenolic compounds and residual chlorophyll, the highest amount of ascorbic acid with a value of 39.77 was related to the samples treated in ethyloleate solution with a concentration of 4% and 4% NaCl and the minimum value of 17.98 was related to the control treatment. The highest amount of residual chlorophyll was 23.6 in the pretreated samples with a concentration of 4% ethyloleate and 4% NaCl and the lowest amount was related to the control sample with a concentration of 12.9%. The color of the dried samples showed that the lowest amount of color changes was related to the non-blanching sample with 4% ethyloleate and 4% NaCl with a value of 4.94. While the blanching and ethyloleate solution had no positive effect on the color of pepper and dried samples were dark. Comparison of blanching with non-blanching shows that blanching samples cause darkening of the primary color of the samples.The best sample in terms of quality and speed of drying, was belonged to the samples which blanched, treated with 4% solution of ethyloleate and sodium chloride.
 
Conclusion
 In order to achieve the best quality in vacuum drying of pepper samples, pretreatments of blanching and using a concentration of 4% solution of ethyloleate and sodium chloride showed the most desirable quality. The best quality of dried samples were obtained when subjected to constant temperature and pressure during drying conditions. The benefits obtained using the pretreatment of ethyloleate and sodium chloride as an appropriate method of drying include increasing the absorption of water, keeping the chlorophyll, phenolic compounds and vitamin C content with time-saving in drying.

Keywords

• Blanching
• Ethyl oleate
• Response surface methodology
• Sodium chloride
• Sweet pepper (Capsicum annum)
• Vacuum drying

Main Subjects

• Food Technology

References

1. Chemists, A. (1990). Official Methods of Analysis: Changes in Official... - Google Scholar. Supplement. Association of Official Analytical Chemists.
2. Alzamora, S.M., Tapia, M.S., Leunda, A., Guerrero, S.N., Rojas, A.M., Gerschenson, L.N., & Parada-Arias, E. (2000). Minimal preservation of fruits: A cited project. Trends in Food Engineering, 205–225.
3. Arévalo-Pinedo, A., & Murr, F.E.X. (2006). Kinetics of vacuum drying of pumpkin (Cucurbita maxima): Modeling with shrinkage. Journal of Food Engineering, 76(4), 562–567. https://doi.org/10.1016/J.JFOODENG.2005.06.003
4. Arévalo-Pinedo, A., & Xidieh Murr, F.E. (2007). Influence of pre-treatments on the drying kinetics during vacuum drying of carrot and pumpkin. Journal of Food Engineering, 80(1), 152–156. https://doi.org/10.1016/J.JFOODENG.2006.05.005
5. Balzarini, M.F., Reinheimer, M.A., Ciappini, M.C., & Scenna, N.J. (2018). Comparative study of hot air and vacuum drying on the drying kinetics and physicochemical properties of chicory roots. Journal of Food Science and Technology, 55(10), 4067–4078. https://doi.org/10.1007/S13197-018-3333-5/METRICS
6. Cichowska, J., Żubernik, J., Czyżewski, J., Kowalska, H., & Witrowa-Rajchert, D. (2018). Efficiency of osmotic dehydration of apples in Polyols solutions. Molecules, 23(2), 446. https://doi.org/10.3390/MOLECULES23020446
7. Daood, H.G., Kapitány, J., Biacs, P., & Albrecht, K. (2006). Drying temperature, endogenous antioxidants and capsaicinoids affect carotenoid stability in paprika (red pepper spice). Journal of the Science of Food and Agriculture, 86(14), 2450–2457. https://doi.org/10.1002/JSFA.2639
8. Demiray, E., & Çalışkan Koç, G. (2021). Effect of vacuum drying temperature and pressure on the drying and desorption characteristics, and lovastatin content of the oyster mushroom (Pleurotus ostreatus) slices. Journal of Food Processing and Preservation, 45(3), e15301. https://doi.org/10.1111/JFPP.15301
9. Doymaz, I. (2004). Effect of pre-treatments using potassium metabisulphide and alkaline ethyl oleate on the drying kinetics of apricots. Biosystems Engineering, 89(3), 281–287. https://doi.org/10.1016/J.BIOSYSTEMSENG.2004.07.009
10. Doymaz, I. (2006). Drying kinetics of black grapes treated with different solutions. Journal of Food Engineering, 76(2), 212–217. https://doi.org/10.1016/J.JFOODENG.2005.05.009
11. Doymaz, I., & Ismail, O. (2010). Drying and rehydration behaviors of green bell peppers. Food Science and Biotechnology, 19(6), 1449–1455. https://doi.org/10.1007/S10068-010-0207-7/METRICS
12. Doymaz, I., & Pala, M. (2002). Hot-air drying characteristics of red pepper. Journal of Food Engineering, 55(4), 331–335. https://doi.org/10.1016/S0260-8774(02)00110-3
13. Kaymak-Ertekin, F. (2002). Drying and rehydrating kinetics of green and red peppers. Journal of Food Science, 67(1), 168–175. https://doi.org/10.1111/J.1365-2621.2002.TB11378.X
14. Lee, J., Durst, R., & International, R.W. (2005). AOAC official method: total monomeric anthocyanin pigment content of fruit juices, beverages, natural colorants, and wines by the pH differential method. Usda.Gov. Retrieved June 15, 2023, from https://www.ars.usda.gov/research/publications/publication/?seqNo115=180292
15. Lee, J.H., & Kim, H.J. (2009). Vacuum drying kinetics of Asian white radish (Raphanus sativus) slices. LWT - Food Science and Technology, 42(1), 180–186. https://doi.org/10.1016/J.LWT.2008.05.017
16. Marzuki, S.U., Pranoto, Y., Khumsap, T., & Nguyen, L.T. (2021). Effect of blanching pretreatment and microwave-vacuum drying on drying kinetics and physicochemical properties of purple-fleshed sweet potato. Journal of Food Science and Technology, 58(8), 2884–2895. https://doi.org/10.1007/S13197-020-04789-5/METRICS
17. Materska, M., & Perucka, I. (2005). Antioxidant activity of the main phenolic compounds isolated from hot pepper fruit (Capsicum annuum). Journal of Agricultural and Food Chemistry, 53(5), 1750–1756. https://doi.org/10.1021/JF035331K
18. Orikasa, T., Ono, N., Watanabe, T., Ando, Y., Shiina, T., & Koide, S. (2018). Impact of blanching pretreatment on the drying rate and energy consumption during far-infrared drying of Paprika (Capsicum annuum). Food Quality and Safety, 2(2), 97–103. https://doi.org/10.1093/FQSAFE/FYY006
19. Tunde-Akintunde, T.Y. (2010). Effect of pretreatment on drying time and quality of chilli pepper. Journal of Food Processing and Preservation ,34(4), 595–608. https://doi.org/10.1111/J.1745-4549.2008.00360.X
20. Vega-Gálvez, A., Di Scala, K., Rodríguez, K., Lemus-Mondaca, R., Miranda, M., López, J., & Perez-Won, M. (2009). Effect of air-drying temperature on physico-chemical properties, antioxidant capacity, colour and total phenolic content of red pepper (Capsicum annuum, L. var. Hungarian). Food Chemistry, 117(4), 647–653. https://doi.org/10.1016/J.FOODCHEM.2009.04.066
21. Yam, K.L., & Papadakis, S.E. (2004). A simple digital imaging method for measuring and analyzing color of food surfaces. Journal of Food Engineering, 61(1), 137–142. https://doi.org/10.1016/S0260-8774(03)00195-X
22. Zirjani, L., & Tavakolipour, H. (2010). The effect of different pre-processes in the process of drying bananas by microwave. Iranian Food Science and Technology, 6(1), 58-67.