Investigating the Effect of Ozone on the Physicochemical, Microbial and Sensory Properties of Brined Ultrafiltered Cheese During Ripening

Document Type : Full Research Paper

Authors

• Aliakbar Gholamhosseinpour ¹
• Ali Karimi Davijani ¹
• Mostafa Karami ²

¹ Department of Food Science and Technology, Faculty of Agriculture, Jahrom University, Jahrom, Iran

² Department of Food Science and Technology, Faculty of Food Science and Technology, Bu-Ali Sina University, Hamedan, Iran

https://doi.org/10.22067/ifstrj.2023.81663.1244

Abstract

Introduction
 Cheese is the general name of a group of fermented dairy products that are produced all over the world in a variety of flavors, textures, and shapes. This product considered a source of protein, minerals, and vitamins, all of which add to its high nutritional value. White-brined cheeses are soft cheeses that ripen in brine. Brined ultrafiltered cheese, as a popular product, has attracted a broad consumer market in our country. The use of thermal processes to prolong the shelf life of foods has long been considered, but these methods lead to a decrease in nutritional value and product quality. Emerging non-thermal technologies, including ultrasound, pulsed electric field, high hydrostatic pressure, cold plasma and ozone have revolutionized the food processing sector. These processes can improve the safety and quality of food products and increase their shelf life by reducing food spoilage. In addition to expanding food shelf life, these technologies are experiencing more orogress  in the industry due to reduced energy consumption. Ozone is one of the most effective disinfectants known that does not leave any dangerous residue on food or other surfaces in contact. Ozone treatment does not require heat and therefore saves energy. Ozonation, as a novel technology, is widely used in preserving meat, processing oysters, inhibiting microbial growth, and oxidizing phenolic compounds. Ozone has been mainly used in the dairy industry to reduce or inhibit the growth of pathogenic or spoilage microorganisms. However, its effect on the non-microbial properties of dairy products has not been studied much.
 
Materials and Methods
 Cheese production was carried out by ultrafiltration technology in the Hamedan Pegah dairy complex (Hamedan, Iran). The starter culture used in cheese production was R708 (containing Lactococcus lactis subsp. cremoris and Lactococcus lactis subsp. lactis), which was obtained from Christian Hansen, Denmark. Microbial renin enzyme (Proteria, Handry Company, Belgium) was also used for coagulation. Analytical grade chemicals were also purchased from Merck, Darmstadt, Germany. Ozone gas at concentrations of 2 and 5 ppm was used in different stages of brined ultrafiltered cheese production and then the samples were subjected to physicochemical (total solids (TS), ash, pH, salt, protein, fat, acid degree value (ADV)), microbiological and organoleptic (based on the 5-point hedonic scale) analyses at 35-day intervals during a ripening period of 105 days. The studied treatments were: Ozonization of retentate simultaneously with starter inoculation (OA), Ozonization of retentate before starter inoculation (OB), Ozonization of retentate (before starter inoculation) and brine (OC), Ozonization of brine (OD) and control (C). Statistical analysis (One-way ANOVA and Duncan) was performed at a significance level of 95% by the SPSS package program (v. 20.0, Chicago, IL, USA).
 
 
Results and Discussion
 Based on the results, the amounts of total solids, ash, salt, ADV and syneresis of cheeses increased significantly (p ≤ 0.05), while the protein and fat contents of the samples decreased significantly (p ≤ 0.05) during the ripening period. The pH of the samples decreased from day 0 to 35 and then increased in most samples until the end of the ripening period. The total counts in the samples increased initially until day 70 but then decreased until the end of the ripening period. In general, during the ripening, cheeses treated with 5 ppm ozone had lower microbial load and higher lipolysis compared to samples treated with 2 ppm ozone. In addition, in most treatments, the sensory scores of cheese samples at the end of the ripening period were significantly (p ≤ 0.05) higher than those at the beginning of the ripening period. The application of ozone treatment was able to improve some of the sensory properties of the cheeses. In general, this improvement was not statistically significant compared to the control, especially at the end of the ripening period.
The positive microbial and physicochemical effects of ozone treatment on cheese samples leading to increase the shelf life of brine cheese up to 105 days (30 days more than usual) without having a negative effect on its sensory properties. Therefore, ozone can be used as a non-thermal treatment to extend shelf life and improve some physicochemical characteristics of cheese.
 

Keywords

• Brined cheese
• Ozonation
• Physicochemical properties
• Storage period

Main Subjects

• Food Technology

©2023 The author(s). This is an open access article distributed under Creative Commons Attribution 4.0 International License (CC BY 4.0), which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source.

References

1. Alexopoulos, A., Plessas, S., Kourkoutas, Y., Stefanis, C., Vavias, S., Voidarou, C., Mantzourani, I., & Bezirtzoglou, E. (2017). Experimental effect of ozone upon the microbial flora of commercially produced dairy fermented products. International Journal of Food Microbiology, 246, 5-11. https://doi.org/10.1016/j.ijfoodmicro.2017.01.018
2. Allai, F.M., Azad, Z.A.A., Mir, N.A., & Gul, K. (2022). Recent advances in non-thermal processing technologies for enhancing shelf life and improving food safety. Applied Food Research, 100258. https://doi.org/10.1016/j.afres.2022.100258
3. (2005). Official Methods of Analysis of the AOAC (Association of Official Analytical Chemists) International, G. W. Latimer and W. Horwitz (Eds.), 18th ed, in total solids (TS) matter (oven-drying method) method 926.08, ash (incineration at 550ºC method) method 935.42, protein content (micro-Kjeldahl method) method 920.123, Gaithersburg, MD.
4. Atasoy, A.F., & Türkoğlu, H. (2008). Changes of composition and free fatty acid contents of Urfa cheeses (a white-brined Turkish cheese) during ripening: Effects of heat treatments and starter cultures. Food Chemistry, 110, 598-604. https://doi.org/10.1016/j.foodchem.2008.02.046
5. Ayyash, M., Abu-Jdayil, B., Hamed, F., & Shaker, R. (2018). Rheological, textural, microstructural and sensory impact of exopolysaccharide-producing Lactobacillus plantarum isolated from camel milk on low-fat akawi cheese. Lwt, 87, 423-431. https://doi.org/10.1016/j.lwt.2017.09.023
6. Beig Mohammadi, M., Bolandi, M., & Ghodusi, H.B. (2015). Production and physicochemical, rheological, sensory analysis of “Lour” cheese. Journal of Food Science and Technology (Iran), 12, 41-49
7. (1989). Standard no. 696: Gerber method for the determination of fat in milk and milk products. London, UK: British Standards Institution.
8. Cankurt, H. (2019). The effects of adding different stabilizers in brine on the physicochemical, sensory, microbiological and textural properties of white cheese. Foods, 8, 133. https://doi.org/10.3390/foods8040133
9. Cavalcante, D., Júnior, B.L., Tribst, A., & Cristianini, M. (2013). Microbiological quality of Minas Frescal cheese treated with ozonated water. International Food Research Journal, 20, 2911
10. Clark, S., Costello, M., Drake, M., & Bodyfelt, F. (2009). The sensory evaluation of dairy products. Springer. https://doi.org/10.1007/978-0-387-77408-4
11. Diezhandino, I., Fernández, D., González, L., McSweeney, P., & Fresno, J. (2015). Microbiological, physico-chemical and proteolytic changes in a Spanish blue cheese during ripening (Valdeón cheese). Food Chemistry, 168, 134-141. https://doi.org/10.1016/j.foodchem.2014.07.039
12. Dorosti, S., Bazmi, A., Ghanbarzadeh, B., & Ayaseh, A. (2011). Effect of brine concentration on the physicochemical properties of Iranian White cheese. Journal of Food Science and Technology (Iran), 8, 1-10
13. Eglezos, S., & Dykes, G.A. (2018). Reduction of environmental listeria using gaseous ozone in a cheese processing facility. Journal of Food Protection, 81, 795-798. https://doi.org/10.4315/0362-028X.JFP-17-361
14. Forouzan, S., Khosroushahi Asl, A., Taslimi, A., Madadadlou, A., & Mashayekh, M. (2009). Study of the effects of microbial, recombinant and animal rennets on some of the qualitative and quantitative properties of Iranian white cheese. Journal of Food Science and Technology (Iran), 6, 63-72
15. Gholamhosseinpour, A., Tehrani, M.M., & Razavi, S.M.A. (2022). The effects of commercial mixed-strain starter cultures on the chemical and sensory characteristics of UF-Feta cheese analogue during ripening. Iranian Food Science & Technology Research Journal, 17(6). https://doi.org/10.22067/ifstrj.2021.70493.1050
16. Gobbetti, M., Burzigotti, R., Smacchi, E., Corsetti, A., & De Angelis, M. (1997). Microbiology and biochemistry of Gorgonzola cheese during ripening. International Dairy Journal, 7, 519-529. https://doi.org/10.1016/S0958-6946(97)00047-2
17. Grasso, C., Eramo, V., Lembo, M., Forniti, R., Carboni, C., & Botondi, R. (2023). Effects of gaseous ozone treatment on the mite pest control and qualitative properties during ripening storage of pecorino cheese. Journal of the Science of Food and Agriculture, 103, 2124-2133. https://doi.org/10.1002/jsfa.12400
18. Gunasekaran, S., & Ak, M.M. (2002). Cheese rheology and texture. CRC press.
19. Hamdy, A.M., Ahmed, M.E., Mehta, D., Elfaruk, M.S., Hammam, A.R., El‐Derwy, Y.M. (2021). Enhancement of low‐fat Feta cheese characteristics using probiotic bacteria. Food Science & Nutrition, 9, 62-70. https://doi.org/10.1002/fsn3.1889
20. Hayaloglu, A.A., Fox, P.F., Guven, M., Cakmakci, S. (2007). Cheeses of Turkey: 1. Varieties ripened in goat-skin bags. Le Lait, 87, 79-95. https://doi.org/10.1051/lait:2007006
21. Hwang, J., Lee, S., Park, H., Min, S., & Kwak, H. (2007). Comparison of physicochemical and sensory properties of freeze-concentrated milk with evaporated milk during storage. Asian-Australasian Journal of Animal Sciences, 20, 273-282. https://doi.org/10.5713/ajas.2007.273
22. (1988). Cheese and processed cheese-determination of salt content. Standard 12 B. Brussels, Belgium: International Dairy Federation.
23. (2015). Microbiology of the food chain, horizontal method for the enumeration of microorganisms, Part 1: colony count at 30 °C by the pour plate technique. Iran National Standards Organization, No. 5272-1.
24. (2019). Microbiology of milk and milk products, Specifications and test methods, Amd. No.1. Iran National Standards Organization, No. 2406-1.
25. (2022). Milk and milk products, determination of titrable acidity and pH, test method. Iran National Standards Organization, 2nd Revision, No. 2852.
26. Karami, M., Ehsani, M., Mousavi, S., Rezaei, K., & Safari, M. (2009). Microstructural properties of fat during the accelerated ripening of ultrafiltered-Feta cheese. Food Chemistry, 113, 424-434. https://doi.org/10.1016/j.foodchem.2008.07.104
27. Karimi, R., Mortazavian, A., & Karami, M. (2012). Incorporation of Lactobacillus casei in Iranian ultrafiltered Feta cheese made by partial replacement of NaCl with KCl. Journal of Dairy Science, 95, 4209-4222. https://doi.org/10.3168/jds.2011-4872
28. Kaya, S. (2002). Effect of salt on hardness and whiteness of Gaziantep cheese during short-term brining. Journal of Food Engineering, 52, 155-159. https://doi.org/10.1016/S0260-8774(01)00098-X
29. Khadre, M., Yousef, A., & Kim, J.G. (2001). Microbiological aspects of ozone applications in food: a review. Journal of Food Science, 66, 1242-1252. https://doi.org/10.1111/j.1365-2621.2001.tb15196.x
30. Kunicka‐Styczyńska, A., & Rajkowska, K. (2011). Physiological and genetic stability of hybrids of industrial wine yeasts Saccharomyces sensu stricto complex. Journal of Applied Microbiology, 110, 1538-1549. https://doi.org/10.1111/j.1365-2672.2011.05009.x
31. Lopez, C., Camier, B., & Gassi, J.-Y. (2007). Development of the milk fat microstructure during the manufacture and ripening of Emmental cheese observed by confocal laser scanning microscopy. International Dairy Journal, 17, 235-247. https://doi.org/10.1016/j.idairyj.2005.12.015
32. Marrone, R., Balestrieri, A., Pepe, T., Vollano, L., Murru, N., Michael, J., & Anastasio, A. (2014). Physicochemical composition, fatty acid profile and cholesterol content of “Pecorino Carmasciano” cheese, a traditional Italian dairy product. Journal of Food Composition and Analysis, 36, 85-89. https://doi.org/10.1016/j.jfca.2014.05.006
33. Milci, S., Goncu, A., Alpkent, Z., & Yaygin, H. (2005). Chemical, microbiological and sensory characterization of Halloumi cheese produced from ovine, caprine and bovine milk. International Dairy Journal, 15, 625-630. https://doi.org/10.1016/j.idairyj.2004.10.009
34. Mohammadi, H., Mazloomi, S.M., Eskandari, M.H., Aminlari, M., & Niakousari, M. (2017). The effect of ozone on aflatoxin M1, oxidative stability, carotenoid content and the microbial count of milk. Ozone: Science & Engineering, 39, 447-453. https://doi.org/10.1080/01919512.2017.1329647
35. Nazari, S.M., Mortazavi, A., Hesari, J., & Tabatabaei Yazdi, F. (2020). Proteolysis and textural properties of low‐fat ultrafiltered Feta cheese as influenced by maltodextrin. International Journal of Dairy Technology, 73, 244-254. https://doi.org/10.1111/1471-0307.12642
36. Nunez-Elisea, R., & Davenport, T.L. (1986). Abscission of mango fruitlets as influenced by enhanced ethylene biosynthesis. Plant Physiology, 82, 991-994. https://doi.org/10.1104/pp.82.4.991
37. O'Donnell, C., Tiwari, B.K., Cullen, P., & Rice, R.G. (2012). Ozone in food processing. John Wiley & Sons.
38. Özer, B., Robinson, R., & Grandison, A. (2003). Textural and microstructural properties of urfa cheese (a white‐brined Turkish cheese). International Journal of Dairy Technology, 56, 171-176. https://doi.org/10.1046/j.1471-0307.2003.00100.x
39. Perna, A., Gambacorta, E., Simonetti, A., Grassi, G., & Scopa, A. (2022). Effect of ozone treatment exposure time on oxidative stability of cream milk. European Journal of Lipid Science and Technology, 124, https://doi.org/10.1002/ejlt.202100238
40. Şanlıbaba, P., & Güçer, Y. (2015). Antimicrobial activity of lactic acid bacteria. Journl International Science Publication, 3, 451-457.
41. Sarbazi, M., Hesari, J., Azadmard-Damirchi, S., & Rafat, S. (2015). Effect of pasteurization and packaging on the physicochemical and sensory properties of pot (Kope) cheese. Journal Food Research and Technology, 24, 507-517.
42. Segat, A., Misra, N., Fabbro, A., Buchini, F., Lippe, G., Cullen, P.J., & Innocente, N. (2014). Effects of ozone processing on chemical, structural and functional properties of whey protein isolate. Food Research International, 66, 365-372. https://doi.org/10.1016/j.foodres.2014.10.002.
43. Sert, D., & Mercan, E. (2021). Assessment of powder flow, functional and microbiological characteristics of ozone-treated skim milk powder. International Dairy Journal, 121, https://doi.org/10.1016/j.idairyj.2021.105121
44. Sert, D., Mercan, E., & Kara, Ü. (2020). Butter production from ozone-treated cream: Effects on characteristics of physicochemical, microbiological, thermal and oxidative stability. LWT, 131, https://doi.org/10.1016/j.lwt.2020.109722
45. Shahab-Lavasani, A.R., Ehsani, M.R., Mirdamadi, S., & Ebrahim Zadeh Mousavi, M.A. (2012). Changes in physicochemical and organoleptic properties of traditional Iranian cheese Lighvan during ripening. International Journal of Dairy Technology, 65, 64-70. https://doi.org/10.1111/j.1471-0307.2011.00724.x
46. Shanshool, A. (2020). Study the effect of ozone gas in milk treatment on chemical and microbial properties of soft cheese ozone gas effect on milk. Indian Journal of Ecology, 47.
47. Sheelamary, M., & Muthukumar, M. (2011). Effectiveness of ozone in inactivating Listeria monocytogenes from milk samples. World Journal of Young Researchers, 1, 40-44
48. Soleimani-Rambod, A., Zomorodi, S., Mortazavi, S.A., & Khosroshahi Asl, A. (2015). The effect of direct acidification of milk on the viability of Bifidobacterium lactis (B94 LAFTI) during ripening of Iranian white cheese. Journal of Innovation in Food Science and Technology, 7, 26-31
49. Suprapto, D., Radiati, L.E., Mahdi, C., & Evanuarini, H. (2021). Physicochemical quality and microbial activity of dairy milk with ozonation. Jurnal Ilmu dan Teknologi Hasil Ternak (JITEK), 16, 117-124. https://doi.org/10.21776/ub.jitek.2021.016.02.5
50. Tabla, R., & Roa, I. (2022). Use of gaseous ozone in soft cheese ripening: Effect on the rind microorganisms and the sensorial quality. LWT, 170, https://doi.org/10.1016/j.lwt.2022.114066
51. Varga, L., & Szigeti, J. (2016). Use of ozone in the dairy industry: A review. International Journal of Dairy Technology, 69, 157-168. https://doi.org/10.1111/1471-0307.12302
52. Zonoubi, R., & Goli, M. (2021). The effect of complete replacing sodium with potassium, calcium, and magnesium brine on sodium‐free ultrafiltration Feta cheese at the end of the 60‐day ripening period: Physicochemical, proteolysis–lipolysis indices, microbial, colorimetric, and sensory evaluation. Food Science & Nutrition, 9, 866-874. https://doi.org/10.1002/fsn3.2050