Document Type : Research Article

Authors

Department of Food Science and Technology, Gorgan University of Agricultural Sciences and Natural Resources, Iran.

Abstract

Introduction: Sourdough is a very complex biological system and an important modern fermentation method of cereal flours and water. Sourdough fermentation is based on lactic acid and alcoholic fermentation depending on the composition of micro flora and fermentation conditions. Commercial sourdough processes do not rely on fortuitous flora but on the use of specific starter cultures. There has also been much progress in the development of tools that allow for the selection of key sourdough microorganisms for particular activities such as those concerned with enzymatic, antimicrobial, nutritional and additive replacement aspects. Most of the beneficial properties attributed to sourdough are determined by the acidification activity of dominant Lactobacillus starters. Sourdough fermentation can improve texture and palatability of whole grain fiber-rich, stabilize or increase levels of various bioactive compounds, retard starch retro-gradation and improve mineral bioavailability. The acidification of the sourdough and the partial acidification of the bread dough will impact on structure-forming components like gluten, starch and arabinoxylans. The swelling of gluten in acid is a well-known effect and mild acid hydrolysis of starch in sourdough systems has also been hypothesized for delay bread staling. The objectives of this research were to apply the dominant Lactobacillus starter isolated from traditional sourdough for cup bread production with whole wheat flour and delay it's staling. Materials and methods: In this study, following isolation of dominant Lactobacillus starter from traditional sourdough produced with whole wheat flour, the starter was identified by specific PCR. The single colonies obtained from streak plate of the sourdough culture, were subjected to species specific PCR. Afterwards, the mentioned starter was used for sourdough preparation. For this purpose, the effect of flour components (extraction rate, moisture, protein, ash and falling number), fermentation times (8, 16, 24 h) and sugar contents (0.5, 1, 1.5%) on starter activity were evaluated. pH and total titratable acidity (TTA) of sourdough treatments were measured. After processing of cup breads with sourdough treatments, the staling of these breads were also examined 2, 48 and 96 h after baking, based on crumb firmness (texture analysis) and amount of porosity (Image j method). Finally for statistical analysis a completely randomized design with factorial arrangement and 3 replications was used. To study the relationship between bread hardness and porosity with fermentation conditions, multiple linear regression was used and regression models were exhibited. Results and Discussion: By sequencing of the PCR products (obtained from sourdough culture), dominant Lactobacillus starter was identified as Lactobacillus plantarum. The TTA profile for the sourdoughs was also quite similar (starters interestingly continue to produce acid) and by increasing of TTA, the pH values were decreased. The acid production depends on factors such as fermentation temperature, time and dough yield. In general, a higher temperature, a higher water content of sourdough and the utilization of whole meal flour enhances the production of acids in wheat sourdoughs. The effect of sourdough on softness improvement was partly due to a higher porosity. Among the bread samples, 96 h after baking, lowest crumb firmness was observed in sample produced with sourdough with 24 h fermentation and 0.5%. sugar content. The maximum amount of crumb firmness was observed in sample produced with sourdough after 8 h fermentation and 1.5% sugar content. Furthermore, the maximum amount of porosity was obtained after 24 h sourdough fermentation and 1.5% sugar content, while the lowest amount was obtained after 8 h sourdough fermentation and 0.5% sugar content. After evaluation the results of texture analysis and porosity tests, significant correlation coefficients were established between porosity and softness, and it is reported that volume improvement is the main reason for a better shelf life in sourdough breads. The relationship between factors affecting on sourdough fermentation including fermentation time, sugar content and flour components, were also exhibited as regression models for examination texture characteristics of sourdough breads based on those viscoelastic behavior. By increasing the fermentation time in all of the sourdoughs, crumb hardness was decreased. Acids strongly influence the mixing behavior of doughs. Doughs with lower pH values require a slightly shorter mixing time and have less stability than normal doughs. Fundamental rheological evaluation of acid effect on gluten systems model indicated that both softness and elasticity of gluten were increased. Further to the direct impact of low pH on dough characteristics, secondary effects of acidification and fermentation time including changes in the activity of cereal or bacterial enzymes associated. Wheat flour proteases have optimal activity around pH=4. In addition, proteolytic enzymes with acidic pH optima in vital wheat gluten have been detected. Process requirements for optimum quality were strain-specific and different for textural improvement which should be taken in to account in designing future sourdough baking processes. According to results of this research, the influence of sourdough on bread softness during storage was depended on fermentation conditions and significant effect of sourdough process conditions on bread staling was clarified in comparison to control sample.

Keywords

AACC International. 2010. AACC methods 46-30. Approved methods of the American association of cereal chemists. 11th Ed. The St. Paul.
AOAC Method. 2003. in official methods of analysis. Association of official analytical chemists. 17th Ed. Arlington.Virginia.
Arendt, E.K., Ryan, L.A.M. and Dal Bello, F. 2007. Impact of sourdough on the texture of bread. Food Microbiology. 24, 165-174.
Barber, B., Ortola, C., Barber, S., and Fernandez, F. 1992. Storage of packaged white bread. III. Effect of sourdough and addition of acids on bread characteristics. ZLebensm Unters Forsch. 194, 442-449.
Bechtel, W.G., Meisner, D.F., and Bradley, W.B. 1953. The effect of crust on the staling of bread. Cereal Chemistry. 30, 160-168.
Birkhed, D., and Fuchs, G. 1975. Influence of sugar content in soft bread on pH of human dental plaque. Acta Odont. 33, 59-66.
Brandt, M.J., and Hammes, W.P. 2001. Einfluß von Fructosanen auf die Sauerteig fermentation. Getreide, Mehl und Brot. 55, 341-345.
Clarke, C.I., and Arendt, E.K. 2005. A review of the application of sourdough technology to wheat breads. Advance in Food and Nutrition Research. 49, 137-156.
Clarke, C.I., Schober, T.J., Dockery, P., O’Sullivan, K., and Arendt, E.K. 2004. Wheat sourdough fermentation: effects of time and acidification on fundamental rheological properties. Cereal Chemistry. 81, 409-417.
Clarke, C.I., Schober, T.J. and Arendt, E.K. 2002. Effect of single strain and traditional mixed strain starter cultures on rheological properties of wheat dough and on bread quality. Cereal Chemistry. 79, 640-647.
Corsetti, A., Gobbetti, M., Balestrieri, F., Paoletti, F., Russi, L., and Rossi, J. 1998. Sourdough lactic acid bacteria effects on bread firmness and staling. Journal of Food Science and Technology. 63, 347–351.
Corsetti, A., and Settanni, L. 2007. Lactobacilli in sourdough fermentation. Food Research International. 40, 539-558.
Crowely, P., Schober, T.J., Clark, C.I., and Arendt, E.K. 2003. The effect of storage time on textural and crumb grain characteristics of sourdough wheat bread. European Food Research Technology. 214, 489-496.
Chavan, R.S., and Jana, A. 2008. Frozen dough for bread making a review. International Journal of Food Science and Technology. 2, 9-27.
Dalbello, F., Clarke, C.I., Ryan, L.A.M., Ulmer, H., Schober, T.J., Strom, K., Sjogren, J., van Sinderen, D., Schnurer, J. and Arendt, E.K. 2007. Improvement of the quality and shelf life of wheat bread by fermentation with the antifungal strain Lactobacillus plantarum FST 1.7. Journal of Cereal Science. 45, 309-318.
Devuyst, L., and Neysens, p. 2005. The sourdough microflora: biodiversity and metabolic interactions. Trends in Food Science & Technology. 16, 43–56.
Devuyst, L., and Vancanneyt, M. 2007. Biodiversity and identification of sourdough lactic acid bacteria. Food Microbiology. 24, 120–127.
Diowksz, A., and Ambroziak, W. 2006. Sourdough. In: Hui, Y.H., Corke, H., De Leyn, I., Nip, and W.K., Cross, N.A. (Eds). Bakery Products. Food Science and Technology. Oxford: Blackwell publishing. 365–388.
Ferchichi, M., Valcheva, R., vost, H., Onno, B., and Dousset, X. 2007. Molecular identification of the microbiota of french sourdough using temporal temperature gradient gel electrophoresis. Food Microbiology. 24, 678–686.
Gobbetti, M. 1998. The sourdough microflora, Interactions of lactic acid bacteria and yeasts. Trend in Food Science and Technology. 9, 267–274.
Gobbetti, M., Smacchi, E., Fox, P., Stepaniak, L. and Corsetti, A. 1996. The sourdough microflora. Cellular localization and characterization of proteolytic enzymes in lactic acid bacteria. LWT Food Science and Technology. 29, 561-569.
Gomez, M., Ronda, F., Caballero, P.A., Blanco, C.A., Rosell, C.M. 2007. Functionality of different hydrocolloids on the quality and shelf-life of yellow layer cakes. Food Hydrocolloids. 21, 167–173.
Gray, J., and Bemiller, J. 2003. Bread staling, Molecular basis and control. Comprehensive Reviews in Food Science and Food Safety. 2, 1–21.
Gul, H., zcelik, S., Sagdic, O., and Certel, M. 2005. Sourdough bread production with Lactobacilli and S. cerevisiae isolated from sourdoughs. Process Biochemistry. 40, 691-697.
Hammes, W.P., Brandt, M.J., Francis, K.L., Rosenheim, M., Seitter, F.H., and Vogelmann, S. 2005. Microbial ecology of cereal fermentations. Trends in Food Science and Technology. 16, 4–11.
Haralick, R.M., Shanmugam, K., and Dinstein, I. 1973. Textural features for image classification. IEEE Transactions of ASAE. 45, 1995-2005.
Izydorczyk, M.S., and Dexter, E. 2008. Barley b-glucan sand arabinoxylans molecular structure, physicochemical properties. International Journal of food Properties. 7, 2850-857.
Katina, K., 2005, Sourdough a tool for the improved flavour, texture and shelf-life of wheat bread. VTT Technical Research Centre of Finland, VTT publication 569. 13-41.
Izydorczyk, M.S., and Dexter, E. 2008. Barley b-glucan sand arabinoxylans molecular structure, physicochemical properties. International Journal of food Properties. 7, 2850-857.
Katina, K., 2005, Sourdough a tool for the improved flavour, texture and shelf-life of wheat bread. VTT Technical Research Centre of Finland, VTT publication 569. 13-41.
Katina, K., Heinio, R.L., Autio, K., and Poutanen, K. 2006. Optimization of sourdough process for improved sensory profile and texture of wheat bread. LWT Food Science and Technology. 39, 1189–1202.
Katina, K., Liukkonen, K.H., Kaukovirta-Norja, A., Adlercreutz, H., Heinonen, S.M., Lampi, A.M., Pihlava, J.M., and Poutanen, K. 2007. Fermentation-induced changes in the nutritional value of native or germinated rye. Journal of Cereal Science. 46, 348–355.
Katina, K., Poutanen, K., and Autio, K. 2004. Influence and interactions of processing conditions and starter culture on formation of acids, volatile compounds and amino acids in wheat sourdoughs. Cereal Chemistry. 81, 598–610.
Korakli, A., Pavlovic, M., Michael, G., and Rudif, V. 2003. Exopolysaccharide and kestose production by Lactobacillus sanfranciscensis LTH 2590. Applied and Environment Microbiology. 69, 2073–2079.
Lacaze, G., Wick, M., and Cappelle, S. 2007. Emerging fermentation technologies: Development of novel sourdoughs. Food Microbiology. 24, 155-160.
Lonner, C., Welander, T., Malin, N., and Dostalek, M. 1986. The microflora in a sourdough started spontaneously on typical Swedish rye meal. Food Microbiology. 3, 3–12.
Maleki, M., Hoseney, R.C., and Mattern, P.J. 1980. Effects of loaf volume, moisture content and protein quality on the softness and staling rate of bread. Cereal Chemistry. 57, 138-140.
Martin, M.L., and Hoseney, R.C. 1991. A mechanism of bread firming. Role of starch hydrolyzing enzymes. Journal of Cereal Chemistry. 68, 503-507.
Meignen, B., Onno, B., Gelinas, P., Infantes, M., Guilois, S., and Cahagnier, B. 2001. Optimization of sourdough fermentation with Lactobacillus brevis and baker's yeast. Food Microbiology. 18, 239-245.
Reale, A., Tremonte, P., Succi, M., Sorrentino, E., and Coppola, R. 2005. Exploration of lactic acid bacteria ecosystem of sourdoughs from the Molise region. Annals of Microbiology. 55, 17–22.
Ribotta, P.D., Cuffini, S., Leon, A.E., and Anon, M.C. 2004. The staling of bread: an X-ray diffraction study. European Food Research Technology. 218, 219-223.
Sadeghi, A., Shahidi, F., Mortazavi, A., and Nassirimahallati, M. 2008. Evaluation of Lactobacillus sanfransicenis (ATCC 14917) and Lactobacillus plantarum (ATCC 43332) effects on Iranian Barbari bread shelf life. African Journal of Biotechnology. 7, 3346-3351.
Siljestrom, M., Bjorck, I., Eliasson, A.C., Lonner, C., Nyman, M., and Asp, N.G. 1988. Effect of polysaccharides during baking and storage of bread. In vitro and in vivo studies. Cereal Chemistry. 65, 1-8.
Simsek, O., Hilmi Con, A. and Tulumoglu, S. 2006. Isolating lactic starter cultures with antimicrobial activity for sourdough processes. Food Control. 17, 263-270.
Shahedi, M. 2002. Factors affecting on the shelf life of bread. First report of wheat production and consumption. Faculty of Agriculture, Tehran University (in Persian).
Shehzad, A., Chiron, H., Della Valle, G., Kansou, K., Ndiaye, A., and Reguerre, A.L. 2010. Porosity and stability of bread dough during proofing determined by video image analysis for different compositions and mixing conditions. Food Research International. 43, 1999–2005.
Standards of flat sangak bread. 2002. Institute of Standards and Industrial Research of Iran. ISIRI number 6943 (in Persian).
Thiele, C., Ganzle M.G., and Vogel, R.F. 2002. Contribution of sourdough lactobacilli, yeast and cereal enzymes to the generation of amino acids in dough relevant for bread flavour. Cereal Chemistry. 79, 45-51.
Venturi, F., Andrich, G., Sanmartin, C., and Zinnai, A. 2013. The kinetics of fermentations in sourdough bread stored at different temperature and influence on bread quality. Journal of Bioprocessing & Biotechniques. 3, 134-138.
CAPTCHA Image